一體化污水處理設備

一體化污水處理設備是将AO工藝A2O等生化處理工藝優化精簡為模組式結構,借鑒國内外污水處理設備先進經驗,最新研發出的新型水處理設備。
在線咨詢
0

産品詳情

undefined
undefined
undefined
undefined
undefined

undefined
undefined
undefined
undefined
undefined


      一體化污水處理設備是将AO工藝A2O等生化處理工藝優化精簡為模組式結構,借鑒國内外污水處理設備先進經驗,最新研發出的新型水處理設備。 

新型一體化污水處理設備結構特點:

1。抗沖擊負荷能力強。設備正常運行後因為其結構原因,水質水量沖擊對設備影響小,但水量如果超過負荷數倍,首先處理效果難以達到,其次
已經挂膜的微生物也會因為水的流速過快而被沖掉。
2,采用前置反硝化既能脫氮又可除磷可用于處理工業廢水、生活污水和城市污水;
3、填料接觸氧化池由軟,重量輕、強度高、物理化學性質穩定,比表面積大,生物膜的粘附能力強,效率高,污水與生物膜接觸面積大。
4、曝氣機的曝氣池采用接觸氧化,使纖維束是不斷流動,曝氣均勻,微生物的生長和成熟快,設備整體啟動迅速,在設備停用後,再次啟用無需重新
調試。
5。出水水質穩定、污泥産量少,容易處理。
6。設備可以安裝在地面或埋入土中,埋在地下。地上可用于綠化、表面結構和少少地在工廠。
7.設備采用plc在線電控,設備可長期自動運轉,無需看管,并可設置在線監控、檢測等功能。
9。設備可以連接到一輛車綜合廢水處理設備。


1. The ability to resist impact load is strong, and the average residence time of contact oxidation method is over 6 hours.
2. It has the ability of denitrification and phosphorus removal and can be used to deal with industrial wastewater, domestic sewage and
urban sewage by adjusting the structure of the equipment. ;
3, most of the fillers in the contact oxidation tank are composed of soft packing, light weight, high strength, stable physical and chemical
properties, large specific surface area, strong biofilm adhesion ability, high contact efficiency between sewage and biofilm.
4, the aerator is used for aeration in the contact oxidation tank, so that the fiber bundle is constantly floating, aeration is uniform, and the
growth of microorganism is mature, which has the characteristics of activated sludge process.
5. The water quality of the effluent is stable, and the production of sludge is less and easy to be treated.
6. The submersible pump can be installed in the equipment to reduce the investment of the project.
7. The equipment can be located on the ground or buried in the ground. When buried in the ground, the upper cover can be used for greening,
less area and less ground structures in the factory.
8. It is easy to complete automatic control and simple management operation.
9. The equipment can be connected to a car to make a mobile integrated sewage treatment equipment.

污水處理設備主要組成:1。水解酸性化池。接觸氧化池。不純槽4。消毒處理。污泥需氧消化池。
1。水解酸性化池
污水處理過程前處理,在對生物廢水的廢水性發酵過程中産生的廢水,這重要的步驟前,直接,後者可以根據時間的一部分廢水處理的效率和治療産生影響,最大的程度的污水處理過程中的效率改善和消費。
2。接觸氧化槽
根據氧化池的幾個等級分,根據共同型水處理的污染的程度加強。一般地治療的時間來判斷。處理時間是,通常的氧化池的使用和治療4 - 6小時的2小時以上的氧化遊泳池的使用超過了4小時以上。主要目的在于,利用對生化學處理的排水的水分解氧化池的加水分解的酸性化池。在原來的廢水分解和淨化的有機材料的大部分是,作為食物的污水中的有機物的載體的好氧細菌,在排水中的有機物的無機鹽分解,達到淨化的目的。需氧性需氧菌菌是為了生存足夠的氧氣,如果沒有充分溶解氧,污水生物化學處理達到目的。需氧的遊泳池,風機提供新的彈性,填充坦克,填料表面面積比、壽命長、簡單的膜和腐蝕抵抗,旋轉混合通風裝置不同,遊泳池底,溶解氧移動速度高、重量輕、年齡引起的,而是被塊并不簡單,使用壽命長。接觸・遊泳池裡水的空氣比約12 : 1。(5~5米3 / h的接觸遊泳水平2)
3。不純油箱
沈降槽内的流水池排水的生物接觸氧化的污水,獨立的生物薄膜和一些有機和無機粒子消除更析出,沈殿槽,重力的原理,懸浮固體物質含有從廢水的底向上方流淌,重力,根據安為材料。為了調整在下降槽的上部出口水位的水堰,下部圓錐形的降水域和污泥煤氣裝置。根據天然氣源的愛好者提供,空氣注冊表的污泥也被送往污泥的好氣消化池。
4。消毒處理
消毒遊泳池«tj 14 - 74»标準是30分鐘。在醫院下水道污水的情況下,1~1~5小時的維持時間增大。本公司,二酸化塩素殺菌裝置使用、殺菌裝置的殺菌池子裡的水的量而劑量不能改變的,更多的水,更多的醫療為了實現少、水和較少的藥的目的,其他的設備,另外需要準備的事作為必要。比如說,工業廢水,以及消毒裝置的消毒池是沒有的。
5。好氣性好氣消化
在水下的污泥排出污泥的量,為了改善污泥的穩定性,在遊泳池的好氣消化和穩定的治療被治療。少堿渣需氧消化清洗後,從污泥箱檢查孔可能得到的tankerage吸引sinotrans後的淤泥水箱底部的吸引了長達(年一次清洗)。上浮液體回流裝置水解酸性化遊泳池澄清的溢出的污泥的需氧上部消化槽的設置。

Main ingredients: 1. Hydrolysis acidification pool. The contact oxidation pond. The impurity of the sedimentation tank 4. Sterilization treatment. Aerobic sludge digestion tank.
1. Hydrolysis acidification pool
In front of the sewage treatment process, the main front of water treatment, it is possible to increase the fermentation wastewater by anaerobic biological wastewater, this is an important step in front of the sewage treatment, and the latter can be directly in the treatment of the wastewater treatment by a part of the time effect on the efficiency and reduce the efficiency and improvement in the maximum degree of consumption of sewage treatment.
2. Contact oxidation tank
Some of the oxidation pool is divided into grades, and according to the degree of the common type of water pollution. In general, it is judged that the time of treatment. The processing time and enhances the oxidation pool is usually used for the treatment of 4 - 6 hours of oxidation pool use no more than four hours. The main purpose of the biochemical treatment of wastewater using catalytic oxidation pond to hydrolysis acidification pool. Most of the organic materials and original wastewater degradation in the purification of the organic matter in sewage with aerobic bacteria for food to a career in the decomposition of organic matter in the waste water, inorganic salt, so as to achieve the purpose of purification. Enough for the survival of aerobic bacteria have oxygen to the aerobic bacteria, dissolved oxygen, to achieve the purpose of biochemical treatment of sewage. The aerobic pool, provided by a blower, a new elastic filling tank, the area ratio of the filler surface, long service life, easy film formation and corrosion resistance, the rotation of the mixing aerator at the bottom of the pool, dissolved oxygen, high speed, light aging by, not easy to be blocked and has a long service life. The water in the pool to contact air ratio is about 12: 1. Back to H level of contact pool.
3. Impurity sedimentation tank
Sewage by biological contact oxidation pond, the flow of water in the settling tank, precipitation, and several of the biofilm removal of organic and inorganic particles, a settling tank, based on the principle of gravity from the wastewater containing suspended solids on the bottom upward flow by gravity materials to calm down. The water weir is provided for adjusting the upper water outlet of the sedimentation tank, and is provided with a sludge gas precipitation area and the lower cone. Provided by the gas source of the fan, and the air stripping by sludge, aerobic sludge digestion tank.
4. Sterilization treatment
The disinfection pool intimate association TJ 74 relation standard for 30 minutes. In the case of hospital sewage disinfection of water in pool, to increase the residence time of 5 hours. The company, which 二酸化塩素殺菌裝置 can change the amount of pond water treatment disinfection sterilizing device by the amount, the more water, in order to realize more medical treatment, less and less water, we need it it is necessary to separately provide with another device. (for example, a disinfection pool. The industrial waste water, and disinfection device.
5. Aerobic sludge digestion
From the settling tank is discharged to reduce the amount of sludge, sludge, in order to improve the stability of sludge treatment in the pool in the treatment of stable and aerobic digestion. Washing sludge aerobic digestion, and less on the suction tank bottom sludge after the suction tankerage Sinotrans available from sludge tank inspection hole (cleaning once a year). In the hydrolytic degradation of supernatant liquid reflux device is set in the acidification pool of aerobic sludge digestion supernatant to the overflow tank top.

 

首頁
電話
短信
聯系